Thor-Burner

Thor-Burner

Thor-Burner

American expendable launch system, a member of the Thor rocket family

The Thor-Burner was an American expendable launch system, a member of the Thor rocket family.[1][2] It consisted of a Thor missile, with one or two Burner upper stages.[1][2] It was used between 1965 and 1976 to orbit a number of satellites, most commonly Defense Meteorological Satellite Program (DMSP) weather satellites. [3] Twenty-four were launched, of which two failed. It weighed 51,810 kg and was 24 metres tall.

Quick Facts Function, Manufacturer ...

Variants

There are many Thor-Burner variations, according to the type of upper stages used:[4]

More information Name, 1st stage ...

Burner-1, MG-18 and Altair

The first two flights used a solid fuel MG-18 as second stage. After than an Altair rocket stage (same as the third stage of some Vanguard launch vehicles) was used, equipped by Boeing with 3-axis control.[5][1]

These combinations were used for six vehicles.[1] The first was launched 1965-01-18 and the sixth 1966-03-30. These were early launches of classified DMSP satellites. Two of these launches failed.[6][1]

  • Thor-LV2D Burner-1 ( MG-18)
    Thor-LV2D Burner-1 ( MG-18)
  • Thor-LV2D Burner-1 ( MG-18)
    Thor-LV2D Burner-1 ( MG-18)
  • Thor-LV2D Burner-1 (Altair-3)
    Thor-LV2D Burner-1 (Altair-3)

Burner-2

The Burner 2 used with the Thor-Burner was the first solid fuel upper-stage vehicle used for general space applications that had full control and guidance capability.[1][7][8][9][10] The first Burner-2 flight was on 1966-09-16.[11][1][7]

On February 19, 1976, the attempted launch of a DMSP satellite from Vandenberg's SLC-10W went awry when SECO occurred 5 seconds early.[12] Although the second stage separated and fired properly, the satellite was left in an unusable orbit from which it decayed only one hour after launch. Investigation into the mishap found that the Thor had been loaded an insufficient amount of RJ-1 (a higher grade of kerosene fuel that offered enhanced performance over standard RP-1) for the mission. The amount of LOX on Thor boosters was always the same on every launch, but the amount of kerosene could vary depending on the engine, as different LR-79 engines had slightly different performance levels, and so factory acceptance data was used to determine the fuel load needed for a particular unit. The particular engine used in Thor 182 had thus been loaded with kerosene according to the data sheet provided by Rocketdyne, however the information contained a typo which led to ground crews loading too little propellant for it. However, the postflight investigation also found that, even if the correct propellant load had been carried, the mission would have still failed because the Thor did not have sufficient performance to loft the DMSP into the required orbit. As the DMSP program evolved, the satellites gradually became heavier and more complex. Program planners, aware of this, selected an LR-79 engine which had particularly high performance, but it still turned out to not be enough for the mission. The failure was thus ultimately attributed to poor mission planning.[13]

  • Thor-LV2F Burner-2
    Thor-LV2F Burner-2
  • Thor-LV2F Burner-2
    Thor-LV2F Burner-2
  • Thor-LV2F Burner-2
    Thor-LV2F Burner-2

Launches

There were twenty six Thor-Burner launches from Vandenberg AFB:[4]

More information Date, Serial ...

References

Wikimedia Commons has media related to Thor-Burner.
  1. [1]
    "Thor with solid-fuel upper stage". Gunter's Space Page. Retrieved 2023-11-29.
  2. [2]
    "Thor Burner". www.astronautix.com. Retrieved 2023-11-29.
  3. [3]
    "Thor Burner 1". www.astronautix.com. Retrieved 2023-11-29.
  4. [4]
    "Thor with solid-fuel upper stage". Gunter's Space Page. Retrieved 2023-11-30.
  5. [5]
    "Thor with a solid fuel top stage". The Satellite Encyclopedia.
  6. [6]
    "Douglas SLV-2 Thor / Boeing (McDonnell Douglas) SB-3 Delta". Directory of U.S. Military Rockets and Missiles.
  7. [7]
    "Thor-LV2F Burner-2". Gunter's Space Page. Retrieved 2023-11-29.
  8. [8]
    "Thor-LV2F Burner-2 Star-13A". Gunter's Space Page. Retrieved 2023-11-29.
  9. [9]
    "Thor-LV2F Burner-2A". Gunter's Space Page. Retrieved 2023-11-29.
  10. [10]
    "Thor Burner 2". www.astronautix.com. Retrieved 2023-11-29.
  11. [11]
    "History - Jets and Moon Rockets: 1957-1970 - The Boeing Company ... Booster Rockets". Boeing. Archived from the original on 2012-05-11.
  12. [12]
    "Thor Burner 2A". www.astronautix.com. Retrieved 2023-11-29.
  13. [13]
    "The Space Review: Launch failures: Two Thors, one problem".


Stub icon

This rocketry article is a stub. You can help Wikipedia by expanding it.
Share this article:

This article uses material from the Wikipedia article Thor-Burner, and is written by contributors. Text is available under a CC BY-SA 4.0 International License; additional terms may apply. Images, videos and audio are available under their respective licenses.